1、系統脫硫液量是影響投資和使用效果關鍵的數據。如果測算量較實際量少，投資估算雖然較低，但按方案確定的首次加量濃度達不到要求，影響使用效果。因此系統脫硫液總量應估算準確，以保證催化劑的初始濃度
1. The amount of desulfurization liquid in the system is the most critical data affecting the investment and use effect. If the measured quantity is less than the actual quantity, although the investment estimation is low, the first dosage concentration determined according to the scheme can not meet the requirements, affecting the use effect. Therefore, the total amount of desulfurization liquid in the system should be estimated accurately to ensure the initial concentration of catalyst
2、催化劑應避光、防潮儲存，儲存環境溫度不宜過高，正常環境儲存質保期為 2年。
2. The catalyst shall be stored away from light and moisture. The storage ambient temperature shall not be too high. The warranty period for normal storage is 2 years.
3、應用后注意監測脫硫液堿度和硫泡沫的分離情況，因硫容高系統硫磺產量會增加，需要關注熔硫釜的處理能力。
3. After application, attention should be paid to monitoring the separation of desulphurizing liquid alkalinity and sulfur foam. Because sulfur content in high sulfur system will increase, the treatment capacity of sulfur melting kettle should be paid attention to.
4、絡合鐵脫硫催化劑在脫硫液中理論上是不消耗的， 但由于在生產過程中催化劑會隨著硫泡沫帶出或溶液損失造成的流失是難以避免的，所以應定期向脫硫液中補充適量的濃縮脫硫催化劑，以維持脫硫液中正常的催化劑濃度.
4. The complex iron desulphurizing catalyst is not consumed theoretically in the desulphurizing liquid. However, because the loss of the catalyst will lead to the loss of sulphur foam or the loss of solution, it is difficult to avoid the desulphurizing solution. Therefore, regular desulfurization catalyst should be regularly added to the desulfurization solution to maintain the normal catalyst concentration in the desulfurization solution.
5、若脫硫負荷超過設計能力太多時，要適當提高吸收劑及催化劑的濃度。
5. If the desulfurization load exceeds the design capacity too much, appropriately increase the concentration of absorbent and catalyst.
6、絡合鐵催化劑雖然有抗油干擾的能力，但是大量焦油、洗油帶入脫硫液而影響脫硫系統的硫泡沫形成，因此要做好入脫硫系統煤氣的預處理工作。
6. Although the complex iron catalyst has the ability to resist oil interference, a large amount of tar and washing oil will bring into the desulfurization solution and affect the formation of sulfur foam in the desulfurization system. Therefore, the pretreatment of the gas into the desulfurization system should be well done.
魯公網安備37011202000764號號 網站地圖XMLTXT
企業二維碼
2021-11-18
